Microneedle devices have been proposed as a minimally invasive delivery system for the intradermal administration of nucleic acids, both plasmid DNA (pDNA) and siRNA, to treat localised disease or ...provide vaccination. Different microneedle types and application methods have been investigated in the laboratory, but limited and irreproducible levels of gene expression have proven to be significant challenges to pre-clinical to clinical progression. This study is the first to explore the potential of a hollow microneedle device for the delivery and subsequent expression of pDNA in human skin. The regulatory approved MicronJet600® (MicronJet hereafter) device was used to deliver reporter plasmids (pCMVβ and pEGFP-N1) into viable excised human skin. Exogenous gene expression was subsequently detected at multiple locations that were distant from the injection site but within the confines of the bleb created by the intradermal bolus. The observed levels of gene expression in the tissue are at least comparable to that achieved by the most invasive microneedle application methods e.g. lateral application of a microneedle. Gene expression was predominantly located in the epidermis, although also evident in the papillary dermis. Optical coherence tomography permitted real time visualisation of the sub-surface skin architecture and, unlike a conventional intradermal injection, MicronJet administration of a 50μL bolus appears to create multiple superficial microdisruptions in the papillary dermis and epidermis. These were co-localised with expression of the pCMVβ reporter plasmid. We have therefore shown, for the first time, that a hollow microneedle device can facilitate efficient and reproducible gene expression of exogenous naked pDNA in human skin using volumes that are considered to be standard for intradermal administration, and postulate a hydrodynamic effect as the mechanism of gene delivery.
Display omitted
Spray-drying represents a viable alternative to freeze-drying for preparing dry powder dispersions for delivering macromolecules to the lung. The dispersibility of spray-dried powders is limited ...however, and needs to be enhanced to improve lung deposition and subsequent biological activity. In this study, we investigate the utility of leucine as a dry powder dispersibility enhancer when added prior to spray-drying a model non-viral gene therapy formulation (lipid:polycation:pDNA, LPD). Freeze-dried lactose-LPD, spray-dried lactose-LPD and spray-dried leucine-lactose-LPD powders were prepared. Scanning electron microscopy showed that leucine increased the surface roughness of spray-dried lactose particles. Particle size analysis revealed that leucine-containing spray-dried powders were unimodally dispersed with a mean particle diameter of 3.12 m. Both gel electrophoresis and in vitro cell (A549) transfection showed that leucine may compromise the integrity and biological functionality of the gene therapy vector. The deposition of the leucine containing powder was however significantly enhanced as evidenced by an increase in gene expression mediated by dry powder collected at lower stages of a multistage liquid impinger (MSLI). Further studies are required to determine the potential of leucine as a ubiquitous dispersibility enhancer for a variety of pulmonary formulations.
The lower respiratory tract provides a number of disease targets for gene therapy. Nebulisation is the most practical system for the aerosolisation of non-viral gene delivery systems. The ...aerosolisation process represents a significant challenge to the maintenance of the physical stability and biological activity of the gene vector. In this study we investigate the role of a condensing polycationic peptide on the stability and efficiency of nebulised lipid–DNA complexes. Complexes prepared from the cationic lipid 1,2-dioleoyl-3-trimethylammonium propane (DOTAP) and plasmid DNA (pDNA) at mass (w/w) ratios of 12:1, 6:1 and 3:1, and complexes prepared from DOTAP, the polycationic peptide, protamine, and pDNA (LPD) at 3:2:1 w/w ratio were nebulised using a Pari LC Plus jet nebuliser. Samples from the nebuliser reservoir (pre- and post-nebulisation) and from the aerosol mist were collected and investigated for changes, including: particle diameter, retention of in-vitro transfection activity and the relative concentration and nature of the complexed pDNA remaining after the nebulisation procedure. The process of jet nebulisation adversely affected the physical stability of lipid:pDNA complexes with only those formulated at 12:1 w/w DOTAP:pDNA able to maintain their pre-nebulisation particle size distribution (145±3 nm pre-nebulisation vs. 142±2 nm aerosol mist) and preserve significant pDNA integrity in the reservoir (35% of pre-nebulisation pDNA band intensity). The LPD complexes were smaller (102±1 nm pre-nebulisation vs. 113±2 nm aerosol mist) with considerably greater retention of pDNA integrity in the reservoir (90% of pre-nebulisation pDNA band intensity). In contrast the concentration of pDNA in the aerosol mist for both the 12:1 w/w DOTAP:pDNA and LPD complexes were significantly reduced (10 and 12% of pre-nebulised values, respectively). Despite reduced pDNA concentration the transfection (% cells transfected) mediated by aerosol mist for the nebulised complexes was comparatively efficient (LPD aerosol mist 26 vs. 40% for pre-nebulised complex; the respective values for 12: 1 w/w DOTAP:pDNA were 12 vs. 28%). The physical stability and biological activity of nebulised lipid:pDNA complexes can be improved by inclusion of a condensing polycationic peptide such as protamine. The incorporation of the peptide precludes the use of potentially toxic excesses of lipid and charge and may act as a platform for the covalent attachment of peptide signals mediating sub-cellular targetting.
Cationic liposomes spontaneously interact with negatively charged plasmid DNA to form a transfection competent complex capable of promoting the expression of a therapeutic gene. This work aims to ...improve the understanding of the poorly defined mechanisms and structural rearrangements associated with the lipid–DNA interaction. Specifically, dimethyl dioctadecylammonium bromide (DDAB):dioleoyl phosphatidylethanolamine (DOPE) and 1,2-dioleoyl-3-trimethylammonium propane (DOTAP) liposomes were mixed with a reporter plasmid (pADβ or pCMVβ) to form lipid–DNA complexes. The size and charge characteristics of the complexes as determined by photon correlation spectroscopy and microelectrophoresis were found to be dependent on the lipid:DNA ratio, with both DDAB:DOPE–DNA and DOTAP–DNA complexes aggregating at around neutral zeta potential. Negative stain transmission electron microscopy demonstrated at least three distinct complex structures being formed at the same DOTAP:DNA ratio. We postulate that two of these aggregates are structural moieties involved in the formation of the efficient transfection particle. Gel electrophoresis was used to determine the efficiency and extent of lipid–DNA complex formation. Results showed that only DOTAP liposomes were capable of preventing ethidium bromide intercalation with DNA and protecting the enclosed plasmid from nuclease digestion. When a range of lipid–DNA complexes were transfected into in vitro cell lines, the efficiency of reporter gene (β-galactosidase) expression was found to depend on the type of liposome used in the complex, the ratio of lipid:DNA and the transfected cell line. Our results challenge the requirement for DOPE to be included in the formulation of cationic lipid vectors, especially in the case of DOTAP containing liposomes.
The skin represents an attractive site for the localised gene therapy of dermatological pathologies and as a potential antigen bioreactor following transdermal delivery. Potential also exists for the ...gene therapy of skin as a cosmetic intervention. The most exploited non-viral gene delivery system involves the complexation of cationic liposomes with plasmid DNA (pDNA) to form lipid:pDNA vectors that protect the DNA from nuclease-mediated degradation and improve transgene-cell interactions. Despite numerous studies examining the potential for these vectors in delivering genes to a variety of keratinocyte models, investigations into the topical application of such complexes to intact skin tissue is limited. This ex-vivo study, conducted with intact skin tissue derived from hairless mice, provides quantitative confirmation that topical administration of cationic lipid:pDNA complexes can mediate uptake and expression of reporter pDNA (33-fold higher compared with control) in viable epidermal tissue. The ex-vivo study design provides for intact skin tissue that has not been subjected to depilatory procedures of potential detriment to stratum corneum barrier function, and can be utilised for the quantitative and efficient examination of a potentially wide range of non-viral gene vectors designed for epidermal expression.
Traditionally, optimisation of a gene delivery formulation utilises a study design that involves altering only one formulation variable at any one time whilst keeping the other variables constant. As ...gene delivery formulations become more complex, e.g. to include multiple cellular and sub-cellular targeting elements, there will be an increasing requirement to generate and analyse data more efficiently and allow examination of the interaction between variables. This study aims to demonstrate the utility of multifactorial design, specifically a Central Composite Design, in modelling the responses size, zeta potential and in vitro transfection efficiency of some prototypic non-viral gene delivery vectors, i.e. cationic liposome-pDNA complexes, and extending the application of the design strategy to more complex vectors, i.e. tri-component lipid:polycation:DNA (LPD). The modelled predictions of how the above responses change as a function of formulation show consistency with an extensive literature base of data obtained using more traditional approaches, and highlight the robustness and utility of the Central Composite Design in examining key formulation variables in non-viral gene delivery systems. The approach should be further developed to maximise the predictive impact of data across the full range of pharmaceutical sciences.
The ges-1 gene of the nematode Caenorhabditis elegans codes for a nonspecific carboxylesterase that is expressed only in the intestinal lineage. This esterase has turned out to be a convenient ...biochemical marker for lineage-specific differentiation. In the present paper, we describe the production of several C. elegans strains that lack detectable activity of the ges-1 esterase. To isolate these ges-1 null strains, we first produced a strain of hermaphrodites in which the wild-type copy of the ges-1 gene was stably balanced over a previously isolated isoelectric focusing allele, ges-1(ca6); this parental strain was then mutagenized with EMS and isoelectric focusing gels were used to identify progeny populations that lacked either ges-1(+) or ges-1(ca6) esterase activity. This method is a straightforward and general approach to obtaining null mutations in any gene that has a biochemical or immunological assay. The ges-1 gene is not essential to worm survival, development or reproduction. Furthermore, lack of the ges-1 product has no obvious effect on the ability of worms (containing either normal or greatly reduced levels of acetylcholinesterases) to survive exposure to esterase inhibitors. The ges-1 gene product provides roughly half of the total esterase activity measured in crude extracts of L1 larvae or mixed worm populations. However, histochemical staining of individual ges-1(0) embryos shows that the ges-1 esterase is the first and essentially the only esterase to be produced during embryonic development, from the midproliferation phase up to at least the twofold stage of morphogenesis. These ges-1(0) strains now allow us to investigate the developmental control of the ges-1 gene by DNA-mediated transformation, in which the ges-1 gene acts as its own reporter.
PDF
